变速箱是一个重要的部分混合汽车变速箱操作得当,可以使汽车石油储蓄,正确操作变速箱,可以延长使用寿命,所以每个人的驾驶搅拌机,必须充分理解传播,在使用的过程中自上料混凝土搅拌罐车变速箱或一些注意事项。

　　Gearbox is an important part of the proper operation of the gearbox of the hybrid vehicle, which can save the oil of the vehicle, operate the gearbox correctly, and prolong the service life. Therefore, everyone's driving mixer must fully understand the transmission, and in the process of use, the variable speed box of the concrete mixer or some precautions.

　　1. 当混合车换挡时，离合器必须完全分离，变速杆必须到位。

　　1. When the mixer is shifting, the clutch must be completely disengaged and the gear lever must be in place.

　　2. 搅拌器的齿轮箱有高档次和低档次之分。停车时，变速箱变速杆应置于低档空档位置。

　　2. The gearbox of agitator can be divided into high-grade and low-grade. When parking, the transmission gear lever should be placed in the low neutral position.

　　3.当搅拌器处于低挡或倒档时，应先停车，然后将其置于档位，以避免损坏传动装置内的部件。当搅拌器处于换挡状态时，必须使用较大的档位来克服换挡锁的阻力。

　　3. When the agitator is in low gear or reverse gear, stop it first, and then put it in gear to avoid damaging the parts in the transmission device. When the agitator is in the shift state, a larger gear must be used to overcome the resistance of the shift lock.

　　4. 当变速器从低档到高档换挡时，不要跳档操作，否则会影响分机同步器的使用寿命。

　　4. When the transmission shifts from low gear to high gear, do not shift, otherwise it will affect the service life of the extension synchronizer.

　　5. 当混合器下坡时，不要改变高低档区。

　　5. When the mixer goes downhill, do not change the high and low range.

　　6. 根据路面情况，搅拌器应从1个或2个街区开始。

　　6. According to the road conditions, the mixer shall start from 1 or 2 blocks.

　　7. 在混合器启动前，应先松开制动器。带止动闸的混合器连接到刹车阀后，必须等待气压上升到要求的压力后才能进入档位。

　　7. Release the brake before starting the mixer. After the mixer with stop brake is connected to the brake valve, it must wait for the air pressure to rise to the required pressure before entering the gear.

　　8. 如果在混合器使用过程中发现变速器有异常声音，且运转明显沉重等异常现象，应立即停机检查，故障排除后继续驱动。

　　8. If the abnormal sound of the transmission is found during the use of the mixer, and the operation is obviously heavy, stop the machine immediately for inspection, and continue to drive after troubleshooting.

　　9. 如果搅拌器在换挡过程中不能进入档位，则需要检查量程缸及其气路，以确保分机进入档位。

　　9. If the agitator cannot enter the gear during the shift, it is necessary to check the range cylinder and its air circuit to ensure that the extension enters the gear.

　　10. 在“三包”期间，一般不允许擅自拆装混合器的变速箱。

　　10. During the period of "Three Guarantees", it is generally not allowed to dismantle the gearbox of the mixer without permission.

　　以上内容由搅拌车整理发布，更多相关信息可以点击官网进行咨询：http://www.jufengjiaobanji.com/

　　The above content is collated and released by Zhongke Jufeng mixer. For more information, please click the official website for consultation: http://www.jufengjiabangji.com/